78
PRECAUTIONS CONCERNING THE ALTERNATOR OPERATION
• The alternator may function only if it is connected to the voltage regulator
and the battery, in order to avoid damages of the current rectifiers and voltage
regulator.
• Battery, connected with inversion of poles, provokes immediate destruction of
the alternator diods.
• Never test the tention presence connecting the jointer with the mass. This will
damage the alternator.
• To charge the battery rapidly and also when it is needed to perform repairs using
electric welding, the battery positive and negative cables should be disconnected,
to avoid damages of the electric components.
• During the engine operation, do not disconnect the battery (also if only for a
moment), because it will provoke danification of the rectifiers diods.
BATTERY
Attention to Risks involved in Battery Handling
Striking matches near the battery may cause explosion of its gases. Use a flashlight
if you need to light up the compartment.
The battery contains an acid that causes burns. Do not contact this acid. If there
is an accidental contact of the acid with your eyes or skin, wash the surface with
plenty of water and immediately see a doctor.
To minimize the danger of an eventual contact of this acid with your eyes, always
use protecting glasses when handling batteries.
Marcopolo S/A – Volare Division is not liable for the accidents resulted from
carelessness or improper handling of the batteries.
Mandatory Battery Recycling
When replacing batteries, return the
used batteries to the dealer. Every
end consumer/user must return used
batteries to dealer/shops. Do not discard
them or throw them at the trash bin.
Points of sale are obliged to accept used batteries and return them to the
manufacturer for recycling purposes.
Risks on handling Acid and Lead
The acid and the lead contained in the battery, if incorrectly discarded into the
environment, may contaminate the ground, the underground and water, as well
as pose risks to the human health.
In case of accidental contact with your eyes or skin, immediately wash with
current water and see a doctor.
Basic composition: lead, diluted sulphuric acid and plastic.