Operation
BX36S
3PH Self-feed Chipper
26
12. Operation
The operator has the responsibility of being
familiar with all operating and safety procedures
and following them.
Although the BX Series 3-point hitch wood chippers
are easy to use, each operator should review this
section to become familiar with the detailed safety and
operating procedures.
12.1 Be Prepared
•
Review the Safety Rules on page 8.
•
Clear the area of bystanders, especially small
children.
•
Each operator must be trained and familiar with the
set up and operation of the Wood Chipper and its
components.
•
Review the Machine Components (see page 19)
•
.Review and follow the Pre-Operation Checklist
•
Review operation and function of the controls (see
•
Survey the work site, move to a clear, level work
area and position at the work site. Do not start the
chipper until it is in position.
•
Set up the machine (see page 26).
•
Each person must wear appropriate
Personal
Protective Equipment (PPE)
whenever operating
the Wood Chipper or working in the vicinity. The
PPE list includes but is not limited to:
• Safety shoes with slip resistant soles.
• Safety goggles or face shield.
• Hearing protection.
• Heavy or leather gloves
Always Wear Personal Protection Equipment
Z94203
12.2 Machine Set-up
Make sure:
•
The chipper is attached to the tractor 3-point hitch.
•
PTO shaft is installed.
•
Hydraulic hoses are connected.
1.
Position the tractor and wood chipper at the work
site.
CAUTION!
Park the machine so prevailing winds blow
exhaust gases / fumes away from the operator.
W006
2.
Set the tractor brake and block / chock the wheels.
3.
Lower the chipper, ensure that the machine is
resting on the ground and is level and stable.
4.
While holding the feed hopper, release the latch
pin from the feed hopper pin tab, and carefully
lower the feed hopper (all models except the
BX36S Series).
Feed Hopper
Lock Pin
Fig. 18 –
Feed hopper lock pin on BX52S, BX72S, BX102S
Summary of Contents for BX36S
Page 1: ...OPERATOR S MANUAL 3PHSelf feedChipper BX36S BX52S BX72S BX102S...
Page 51: ......
Page 52: ...www wallensteinequipment com...
