5
COMPRESSOR
MOUNTING INSTRUCTIONS
MOUNTING COMPRESSOR
• The compressor may be permanently mounted.
• The structure that the compressor is mounted
to must be strong enough to support the full
weight of the compressor. Mounting in a vehicle
will also need to account for road and
off-road conditions.
• Remove the handles with common hand tools.
• Reuse the rubber bumpers to isolate vibration.
• Use the 1/4-20 screws and nuts shown to fasten
the compressor to the mounting structure.
• If the screws are too short, longer 1/4-20
screws must be used.
• Use thread locking compound on screw threads.
BASE
TUBE ASSEMBLY
BUMPER
NUT FOR MOUNTING FOUR PLACES
SCREW FOR MOUNTING FOUR PLACES
6
COMPRESSOR
ELECTRICAL CONNECTIONS
RED CABLE
BLACK CABLE
BATTERY
–
+
Electrical Connections
• Route battery connection cables in areas which will
not cause them to chafe or cut through the insulation
causing a potential short circuit.
• Upon completion of installation, refer to operating
instructions and check compressor for proper
operation.
To avoid serious injury or
death from electrical fire:
• Never route electrical cables:
- Across any sharp edges.
- Through or near moving
parts.
- Near parts that become
hot.
• Always insulate and protect all
exposed wiring and electrical
terminals.
W A R N I N G
CHEMICAL AND FIRE HAZARD
Failure to observe these instructions could
lead to severe injury or death.
• Never operate this unit without a fuse.
• Always replace fuse with the proper type and
rating.
This unit is equipped with a fuse. The red light in the
power switch will not light if the fuse opens. For a
replacement fuse, please contact a Warn Industries,
Inc. service representative.
Part Number
76800
, SPI Compressor: 150 Amp fuse
Part Number
75789
, VTC Compressor: 200 Amp fuse
Warn Industries, Inc.
Phone: 1-800-543-9276
Web: www.warn.com
W A R N I N G
Extreme Environments:
An air inlet filter is recommended for use in extreme
environments to protect your air compressor from
airborne particles that could potentially reduce the life
of your air compressor. Contact WARN Customer service
or your local WARN dealer to purchase Air Filter Kit PN
79260.
Optional Accessories:
Air Accessory Kit
PN
73945
Air Tank Plumbing Kit
PN
73940
Air Tank 2.5 Gallon
PN
73938
Air Tank 5 Gallon
PN
73939
Battery Clamp Kit
PN
79580
Summary of Contents for 75789
Page 42: ......
