Revision 1.0 - 12/08/2013
7
Warnings
Health and Safety
Moving the vehicle
Before driving the vehicle, operators must
familiarise themselves with the vehicle’s
operation guide.
Working on the vehicle
Before commencing work on the vehicle,
take note of all the instructions relating to
safety and hazardous items. The following
potential hazards should be considered.
Stored Energy
Certain components and systems on the
vehicle contain stored energy which must
not be released in a non-approved manner.
Tyre air pressure.
Braking system spring compression, pressure in
the air lines, Hybrid electrical system
Cooling system pressure and temperature.
Coolant in the system will remain hot and
under pressure for some time after use.
Allow to cool before attempting to remove
the header tank cap.
Chassis lifting - adequate support required
during jacking or lifting. Eye protection
should be worn when working under the
vehicle
Diesel injection pumps supply fuel to the
engine at a very high pressure, care must
be taken when working on the injectors or
injection pipes, as fuel under high pressure
can penetrate the skin.
Brake discs will remain at an extremely
high temperature for a considerable
amount of time after use, caution must be
exercised when handling such items to
avoid burns.
Hazardous materials
Certain components on the vehicle contain, or
can produce, material which must be handled
with caution. Theses materials are as follows:
Those which must not be taken internally or
contact the eyes, skin or mouth.
Battery Acid
Diluted sulphuric acid can cause skin
burns, eye damage and internal damage if
ingested. Vapour from the solution can also irritate
the respiratory system and the eyes. Take care
carrying the battery. Hydrogen gas given off by the
battery is highly explosive.
Mineral Oil
This type of oil contains small quantities of
polycyclic aromatic hydrocarbons, which
can cause irritation, dermatitis and oil acne
if allowed persistent contact with the skin.
Toxicity through ingestion is of a low order,
however this should be avoided. If swallowed
or gets into eyes, seek medical advice.
Table Of Contents
