February 2013
2-463
ColorQube® 9303 Family
94-536-00, 94-538-00, 94-540-00, 94-542-00, 94-544-
Status Indicator RAPs
94-536-00, 94-538-00, 94-540-00, 94-542-00, 94-544-00, 94-
546-00, 94-632-00, 94-633-00 Drum Heat Error RAP
94-536-00 Drum front heater is too hot
94-538-00 Drum front heater is heating too slowly
94-540-00 Drum front thermistor is faulty
94-542-00 Drum rear heater is too hot
94-544-00 Drum rear heater is heating too slowly
94-546-00 Drum rear thermistor is faulty
NOTE: Field engineering have observed that the following two fault codes 94-632-00 and 94-
633-00 have appeared during the normal printing process, with 99 % of their occuranceies
having no consequences. Therefore, it is advised that either code can be treated as a soft fault
code and generally ignored unless either fault code reoccurs persistantly.
94-632-00 Drum front heater went unstable while printing
94-633-00 Drum rear heater went unstable while printing
Initial Actions
Check that the machine is installed to allow adequate airflow. Refer to
GP 21
Installation Space
Requirements.
Procedure
WARNING
Ensure that the electricity to the machine is switched off while performing tasks that do
not need electricity. Refer to
GP 14
. Disconnect the power cord. Electricity can cause
death or injury. Moving parts can cause injury.
Enter
dC330
code 42-064 to run the drum fan,
PL 94.20 Item 4
. The fan runs.
Y
N
Go to
WD 9.1
. Check the drum fan.
Refer to:
•
OF 6
Fans and Air Systems RAP
•
GP 10
, How to Check a Motor.
•
P/J501
Drum driver PWB
.
•
01H
+24V Distribution RAP.
•
01L
0V Distribution RAP
Install new components as necessary:
•
Drum fan,
PL 94.20 Item 4
.
•
Drum driver PWB,
PL 1.15 Item 4
.
Enter
dC335
Heater Monitor and Exerciser. Select the front drum heater. Set the Setpoint
Mode to Ready. Select Graph to run the test. Check that the temperature is correct and stable.
Repeat the test for the rear drum heater.
NOTE: If the drum heater test fails to work correctly. Switch the machine off and then on,
GP
14
. Enter
dC335
and rerun the drum heater test.
The tests were good.
Y
N
Go to
WD 1.2
,
WD 9.1
and
WD 9.3
. Check the wiring between:
•
The power supply unit and the drum heaters.
•
The power supply unit and the thermal cutout PWB.
•
The drum driver PWB and the front and rear thermistors.
Refer to:
•
P/J5AC,
Power supply unit.
•
P/J501, P/J801
Drum Driver PWB
•
01A
AC Power Distribution RAP.
•
01B
+3.3V ESTAR Distribution RAP.
•
01L
0V Distribution RAP
Install new components as necessary.
•
Front drum thermistor
PL 94.20 Item 9
•
Rear drum thermistor,
PL 94.20 Item 10
.
•
Drum,
PL 94.20 Item 1
.
•
Drum driver PWB,
PL 1.15 Item 4
.
•
Power supply unit,
PL 1.15 Item 2
.
•
Thermal cutout PWB,
PL 88.10 Item 11
.
The fault may be intermittent. Go to
WD 1.2
,
WD 9.1
and
WD 9.3
. Check for loose connections
between:
•
The power supply unit and the drum heaters.
•
The power supply unit and the thermal cutout PWB.
•
The drum driver PWB and the front and rear thermistors.
Refer to:
•
P/J5AC
Power supply unit.
•
P/J501, P/J801
Drum driver PWB
•
01A
, AC Power Distribution RAP.
•
01B
, +3.3V ESTAR Distribution RAP.
•
01L
0V Distribution RAP
If the fault persists, install new components as necessary.
•
Front drum thermistor,
PL 94.20 Item 9
.
•
Rear drum thermistor,
PL 94.20 Item 10
.
•
Drum,
PL 94.20 Item 1
.
•
Drum driver PWB,
PL 1.15 Item 4
.
•
Power supply unit,
PL 1.15 Item 2
.
•
Thermal cutout PWB,
PL 88.10 Item 11
.
Summary of Contents for ColorQube 9303 Series
