June 2014
2-4
Xerox® Phaser® 3020 Printer Service Manual
06-100 / 200 , 07-110
Status Indicator RAPs
Check the harness for an open or short circuit.. The Harness is OK
Y
N
•
Check that all connections are secure
•
Check that there is no contamination
•
Replace the Harness
PL 3.1
.
Replace the LSU Laser Module (
REP 1.10
),
PL 3.6
.
If the problem is intermittent, check all wiring for open or short circuit.
07-110 Paper Jam or Tray Empty Fault
The Tray Empty Sensor failed to detect paper in the tray.
BSD-Reference:
7.1 Paper Feed and Registration
Initial Actions
Ensure that no paper is loaded in the tray. Clear any jammed sheets. Refer to Section 7: Trou-
bleshooting, in the Xerox® Phaser® 3020 User Guide for detailed instructions on clearing
paper jams.
Procedure
Check the Feed and Width Sensor actuators for damage or binding. The actuators moves
freely and are undamaged.
Y
N
Replace the Feed or Width Sensor Actuator,
PL 3.3
.
Enter Diagnostic (EDC) Mode. Select: [DC330 Component Control, 102 Sensor, Tray 1
Empty]. Block and clear the Feed and Width Sensors. The sensors signals changes.
Y
N
•
Check the connection between the Main PWB and the Feed Sensor PWB for an
open or short circuit and that no contamination is present.
•
Repair or replace parts as necessary .
If the problem is intermittent, check the circuit of the Tray Empty Sensor.
A
B
Summary of Contents for Phaser 3020
