6. Perform the following:
a.
Disconnect the power cord.
b.
Reinstall the hard disk interface PWB.
c.
Connect the power cord, and
perform a self test.
The self test completes without an FP10
error.
Y
N
|
Replace the hard disk interface
PWB.
7. Perform the System Check.
RAP 2.7 E027 Error Code
1. The memory expansion and/or disk drive
option is installed.
Y
N
|
Replace the main PWB. If the
problem still exists, replace the
RAM/ROM PWB.
2. Perform the following:
b.
Remove the option interface PWB(s).
c.
Connect the power cord, and
perform a self test.
The self test completes without an E027
error.
Y
N
|
Replace the main PWB. If the
problem still exists, replace the
RAM/ROM PWB.
3. The hard disk drive option is installed.
Y
N
|
Go to step 5.
4. Go to RAP 8.2B.1.
5. Perform the following:
a.
Disconnect the power cord.
b.
Install the memory expansion PWB.
c.
Connect the power cord, and
perform a self test.
The self test completes without an E027
error.
Y
N
|
Replace the memory expansion
PWB.
6. Perform the System Check.
RAP 2.8 Excessive Motor Noise
During Print Cycle
1. Perform the following:
a.
Disconnect the power cord.
b.
Remove the rear cover (REP 4.1.7).
c.
Remove the lower front cover (REP
4.1.4).
d.
Inspect all belts, gears, and pulleys in
the paper feed and printer areas.
Mechanical components are in good
condition (not broken, not worn, and
free of surface cracks).
Y
N
|
Replace defective component.
2. Perform the following:
a.
Manually rotate the pulley on the
upper printer hinge shaft (rear
frame).
b.
Observe the movement of the gears,
belts, and pulleys in the printer and
paper feed-out areas.
Components move freely with no
binding.
Y
N
|
Repair/replace faulty belt, gear,
and/or pulley.
3. Perform the following:
a.
Open the right side cover.
b.
Manually rotate the gear on the
auxiliary tray drive assembly (rear
frame).
c.
Observe the movement of the gears,
belts, and pulleys in the paper feed
area.
8/91
Telecopier 7032 / 7033 Service Manual
2-21
RAP 2.7, 2.8
www.printcopy.info
www.printcopy.info
Summary of Contents for Telecopier 7032
