Page 25
a. Loosen screws at cable connectors and clamps.
b. Adjust steel support cable to proper length and tighten
screws.
c. Loosen upper cable grip and pull excess cable into
connection box at hoist.
d. Tighten cable grip and cut off excess cable.
e. Strip cable sheath and connect wires with same type of
terminals previously furnished (care must be exercised to
match previous wire color coding with wire markers in
accordance with wiring diagram furnished with hoist.)
SECTION VIII - WIRING DIAGRAMS
Wiring diagrams for SHAW-BOX electric hoists have been
omitted from this book because of many possible variations.
This is due to different currents and types of electrical
components used in their construction. A print of the correct
wiring diagram for each hoist is furnished as a separate insert
and shipped with hoist. We suggest you carefully file the wiring
diagram with this book for future reference.
7-6. SHORTENING OF PUSH BUTTON CABLE.
Be certain that electrical power supply is OFF and
locked in the open position before attempting
shortening of push button cable.
WARNING
The numbers assigned to the parts of our various
assemblies in our parts list are not the part numbers
used in manufacturing the par t. They are
identification numbers, that when given with the
model number, permit us to identify, select or
manufacture, and ship the correct part needed.
SECTION IX - PARTS LIST
9-1. GENERAL. The parts lists and illustrations in this section
of the manual cover parts for all standard and low head room
models Series “700” SHAW-BOX Electric Hoists. A typical hoist
is shown as the basis for the exploded parts illustrations;
therefore, certain variations may occur from the information
given. For this reason, always give the Hoist Serial Number,
Catalog Number, Motor Horsepower, Voltage, Phase, Frequency
and Capacity of Hoist when ordering parts.
SHAW-BOX Series “700” Hoists are built in two basic sizes,
Size 2, and Size 3. To determine the size of your hoist measure
the width of your hoist at the gearcase cover. Size 2 hoists
measure 24-3/4 inches and Size 3 hoists measure 34-1/4
inches. Select part numbers and quantities in the column
corresponding to the size of your hoist.
Certain parts of your hoist will, in time, require replacement
under normal wear conditions. It is suggested that these parts
be purchased for your hoist as spares for future use. These
parts are indicated by a (t) symbol at the side of the parts
reference numbers.
Figure
Page
Title
No.
No.
Frame, Gearcase, Motor and
External Covers .....................................
9-1
26
Suspension Parts for Low Headroom
Hoists .....................................................
9-2
28
Drum, Shaft, Gear and Bearings .............
9-3
29
Mechanical Load Brake Parts
(Includes Overload Clutch Parts) .........
9-4
30
Motor Pinion Shaft, Coupling and
Motor Brake Parts .................................
9-5
31
Motor Brake Actuating Mechanism ..........
9-6
32
Upper Limit Switch Parts -
Block Operated:
Single Reeved Hoists ........................
9-7
33
Double Reeved Hoists .......................
9-7a
34
Low Headroom Hoists .......................
9-8
35
Upper and Lower Limit Switch:
Geared Rotary Type ..............................
9-9
36
Geared Rotary Type ..............................
9-9a
37
9-2.
LIST OF PARTS ILLUSTRATIONS
Figure
Page
Title
No.
No.
Electrical Control Equipment:
Size 2 Hoists .........................................
9-10
38
Size 3 Hoists Thru 15 Tons Only ..........
9-10a
39
Size 3 Hoists, 20 and 25 Tons ..............
9-10b
40
Size 2 Hoists (Later Models) ................
9-10c
42
Size 3 Hoists (Later Models) ................
9-10d
44
Push Button Station and Conductor
Cord Assembly ......................................
9-11
46
Upper and Lower Block Parts
Including Hoist Rope:
Standard Headroom Hoists:
2 thru 7-1/2 Ton - Single Reeved
- 1/4", 5/16", 3/8", 7/16" Rope ........
9-14
48
2 thru 5 Ton - Double Reeved
- 3/8" Rope ......................................
9-16
52
5 thru 15 Ton - Single Reeved
- 9/16" Rope ....................................
9-15
50
Summary of Contents for SHAW-BOX
Page 66: ...NOTES ...
Page 67: ...NOTES ...
