3 - 2
CHK
ADJ
GENERAL MAINTENANCE AND LUBRICATION CHART
GENERAL MAINTENANCE AND LUBRICATION CHART
NOTE:
_
• Recommended brake fluid: DOT 4
• Brake fluid replacement:
• When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally
check the brake fluid level and add the fluid as required.
• On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two
years.
• Replace the brake hoses every four years, or if cracked or damaged.
WARNING
_
Indicates a potential hazard that could result in serious injury or death.
ITEM
ROUTINE
Whichever
comes first
INITIAL
EVERY
month
1
3
6
6
12
km
(mi)
320
(200)
1300
(800)
2500
(1600)
2500
(1600)
5000
(3200)
hours
20
80
160
160
320
Air filter element
• Clean.
• Replace if necessary.
Every 20 ~ 40 hours
(more often in wet or dusty areas)
Clutch*
• Check operation.
• Adjust if necessary.
Front brake*
• Check free play/operation/fluid leakage/See NOTE.
• Correct if necessary.
Rear brake*
• Check operation/fluid leakage/See NOTE.
• Correct if necessary.
Wheels*
• Check balance/damage/runout.
• Replace if necessary.
Wheel bearings*
• Check bearing assemblies for looseness/damage.
• Replace if damaged.
Rear arm pivots*
• Lubricate every 6 months with lithium-soap-based
grease.
Upper and lower arm
pivot and steering
shaft*
• Lubricate every 6 months with lithium-soap-based
grease.
Drive chain
• Check and adjust slack/alignment/clean/lube.
Fittings and fasten-
ers*
• Check all chassis fittings and fasteners.
• Correct if necessary.
Front and rear sus-
pension*
• Check operation.
• Correct if necessary.
Steering system*
• Check operation.
• Repair if damaged.
• Check toe-in.
• Adjust if necessary.
Engine oil
• Replace (Warm engine before draining).
Engine oil filter ele-
ment
• Replace.
Cooling system
• Check coolant leakage.
• Repair if necessary.
• Replace coolant every 24 months.
Lights and switches*
• Check operation.
• Adjust headlight beams.
Summary of Contents for YFM700RV 2009
