SAFETY
ZIPPER MASCHINEN GmbH www.Zipper-Maschinen.at
24
ZI-BRM52EST
Ensure sufficient lighting conditions in the working and surrounding areas of the machine.
Keep hands and feet away from moving machine parts and always ensure a safe stand when
working.
Remove the adjustment tool from the machine before operation.
Never leave the running machine unattended (always stop the machine before leaving it).
Ensure that unauthorised persons maintain a safe distance from the machine and keep
children away from the machine.
The machine may only be operated, serviced or repaired by persons who are familiar with it
and who have been informed of the dangers arising during this work.
Always wear suitable personal protective equipment (ear protection, safety shoes etc.)!
Do not work with the machine if you are tired, not concentrated or under the influence of
medication, alcohol or drugs!
Never operate the unit in the presence of flammable liquids or gases (danger of explosion!).
Carry out maintenance, adjustment and cleaning work only when the engine is switched off.
Only use spare parts and accessories recommended by Zipper machines.
15.4
Special safety instructions for the operation
The machine is designed to be operated by one person. Always operate the machine from
behind. Never stand next to or in front of the machine when the engine is running.
Excessive noise can cause hearing damage and temporary or permanent hearing loss. Wear
hearing protection certified to health and safety regulations to limit noise exposure.
Do not increase the regulated idle speed by your own. This could result in damage to the
machine or personal injury.
15.5
Safety instructions for machines with combustion engine
Do not touch the engine and/or muffler during operation or immediately after switching off!
These areas become hot during operation and can cause burns.
Do not touch the spark plug connector when the engine is running (electric shock!).
Do not operate the unit in closed areas or in poorly ventilated rooms unless there is adequate
ventilation through exhaust fans or hoses. (Risk of suffocation from carbon monoxide!)
Do not smoke while the machine is in operation.
Do not smoke when refuelling the machine.
Refuel the machine only in a well ventilated area.
Do not refuel the machine when the engine is running or the machine is still hot.
Do not refuel the machine near naked flames.
Do not spill fuel when refuelling.
Do not crank a gas flooded engine as long as the spark plug is removed- fuel in the cylinder
sprays out of the spark plug opening.
Do not carry out an ignition spark test on engines if the engine is flooded or gas can be
smelled. A stray spark could ignite the vapours.
Do not use fuel to clean machine parts, especially indoors. Vapours from fuels may explode.
Always keep the area around the muffler free of foreign substances such as leaves, paper,
cardboard, etc. A hot muffler could ignite these substances and cause a fire.
Close the filler cap after refuelling.
Check the fuel line and tank regularly for leaks and cracks. Do not operate the machine if
leaks in the fuel system are known.
Store fuel only in designated and approved containers.
15.6
Safety instructions for using the charger
The battery charger is only suitable for charging the machine's battery that is supplied.
Charging other batteries is not permitted.
Never use the charger in a damp or wet environment.
Only disconnect cable connections by pulling the plug. Pulling on the cable could damage the
cable and plug and electrical safety would no longer be guaranteed.
Never use the charger if the cable, plug or the device itself is damaged by external
influences. Then take the charger to the nearest specialist workshop.
Do not operate the appliance near heat sources.
Never open the charger. In the event of a fault, contact a specialist workshop.
Only use the original charger to charge the battery. Using other chargers may cause defects
or cause a fire.
