Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described.
Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or
property damage! Retain instructions for future reference.
For parts, product & service information
visit
www.chpower.com
REMINDER: Keep your dated proof of purchase for warranty purposes! Attach it to this manual or file it for safekeeping.
IN717801AV 1/10
See Warranty on page 4 for important information about commercial use of this product.
Operating Instructions
CC2410
© 2010 Campbell Hausfeld/Scott Fetzer
Cordless Inflator
Description
The cordless inflator delivers up to 140
psi and serves as a rechargeable 12-volt
power supply. This inflator inflates tires,
rafts and sports equipment and also
powers 12-volt tools and appliances.
Unpacking
When unpacking this product, carefully
inspect for any damage that may have
occurred during transit.
Safety Guidelines
This manual contains information
that is very important to know and
understand. This information is
provided for SAFETY and to PREVENT
EQUIPMENT PROBLEMS. To help
recognize this information, observe the
following symbols.
Danger indicates an
imminently
hazardous situation which, if not
avoided, WILL result in death or serious
injury.
Warning indicates a
potentially
hazardous situation which, if not
avoided, COULD result in death or
serious injury.
Caution indicates a
potentially
hazardous situation which, if not
avoided, MAY result in minor or
moderate injury.
Notice indicates
important
information, that if not followed, may
cause damage to equipment.
General Safety Information
The following safety precautions must
be followed at all times along with any
other existing safety rules:
1. Completely read the manual(s)
included with this product carefully.
Be thoroughly familiar with the
proper use of the unit.
CC2410
Recharge the unit every 3-to-6 months
even if the unit has not been used.
120-VOlt AC reChArGInG
To recharge the battery using the 120-
volt AC adapter, follow the subsequent
procedures:
1. Push the power switch to the OFF
position and insert the 120-volt AC
recharging adapter into the AC
charge input socket located next to
the power switch.
2. Plug the charger into a 120-volt
electrical outlet.
3. The red charging light will come on
indicating the battery is recharging
and will remain on until charger is
removed. No other indicator lights
will come on.
4. Charge the inflator for 14 to 16
continuous hours before initial use.
After multiple uses, recharge the
battery for 7 to 9 hours. If the unit is
used too long after the yellow light
comes on, recharging time could
take up to 20 hours and the battery
life may be shortened.
Do not operate
the unit while
recharging with the 120-volt AC
adapter. Damage will occur to the
charger.
2. Do not continue to operate the
inflator after the yellow battery
indicator light comes on.
3. Only use the enclosed recharging
adapters.
4. Avoid charging the battery at temps
below 40°F (5° C) or above 105°F
(40°C).
Do not operate
the inflator with
the 120-volt AC recharging adapter
connected to the unit because the
charger could become damaged.
5. Never operate the inflator
near fire, flammable gas
or liquid.
6. Never leave unit
unattended while in use.
7. Protect the unit from rain, snow or
other sources of moisture.
8. Do not put metal objects into the
12-volt DC power outlet.
9. Always replace the fuse with the
same amperage rating (10 amp).
Never use a fuse with a higher
amperage rating.
The cordless inflator battery is not fully
charged. The battery must be charged
using either the 120-volt AC or the
12-volt DC recharging adapter before
the initial use. For best results, charge
the battery in temperatures ranging
from 65°F (18°C) to 75°F (24°C).
CAlIfOrnIA prOpOSItIOn 65
This product or
its power cord
contains lead, a chemical known to
the State of California to cause cancer
and birth defects or other reproductive
harm. Wash hands after handling.
Operation
Battery must be
charged before
initial use and if the yellow light comes
on. If the power is totally drained
from the battery and not recharged,
the battery may not be rechargeable.
