This manual describes the installation and operation of the Model FW270029 non-catalytic wood heater.
This heater meets US Environmental Protection Agency’s emission limits for wood heaters. Under specific
conditions this heater has been shown to deliver heat at rates ranging from 10,370 to 29,301 BTU per hour.
6” Flue Required
Figure A: Clearance from combustible constructions
From Heater From Chimney Connector
Sidewall..........17-1/2” (444 mm)
Sidewall.................28”
(711 mm)
Backwall...............13” (330 mm)
Backwall................15-1/2” (394 mm)
Corner...................11” (279 mm)
Corner....................22”
(559 mm)
Ceiling....................54-1/2” (1384 mm)
A
D
B
E
C
F
G
Model No. FW270029
This unit has been listed by Warnock
Hersey Limited to meet or exceed
ULC S-627 Canada and UL 1482 U.S.
Part No S19567 Rev06
NOTE: Retain this sheet for future reference
A minimum clearance of 18” (457mm) to the chimney connector
may be required by the authority having jurisdiction.
MADE IN CANADA BY CFM Corporation, 2695 Meadowvale Boulevard, Mississauga, ON L5N 8A3 800-668-5323
www.cfmcorp.com
Unit must be placed on a noncombustible floor protection equivalent to 3/8” millboard.
Floor protector must have min. R value of .893
Consult your local building authorities for further information.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
OPTIONAL FAN
An optional heat exchange blower is available for
this wood burning appliance. To order please see
the local dealer where you purchased your appliance.
CAUTION:
Do not open fire-door to a point where it
would be in contact with the combustible sidewall.
3FT(1M) MIN
FROM ROOF
PENETRATION
MINIMUM OVERALL
HEIGHT FROM FLOOR
15FT(5M)
G
2ft(635mm) HIGHER THAN
NEAREST POINT OF
ROOF WITHIN 10ft(3M)
B
E
A
D
8”(203mm)
BACK WALL
SIDE W
ALL
BACK WALL
C
F
C
F
SIDE W
ALL
Figure “A”
*16
**18
*16”(406mm) U.S.A.
**18”(457mm) Canada
8”(203mm)
8”(203mm)
Inlet Air Control Settings
Desired Burn Setting Inlet Air Setting **Approx. BTU Output
Low Closed Fully 10,370
Med / Low ¼ Open 12,420
Med / High ¾ Open 15,676
High Fully Open 29,301
**Performance may vary depending on actual home operating conditions
2 FULL BRICKS
BAFFLE ASSEMBLY
BE SURE TO INSTALL TWO
FULL BRICKS (S16040) IN
BAFFLE AS SHOWN
13
13
13
13
13
13
13
13
14 14
14
14
15
16
16
19
17
Brick Pattern
Disposition Des Briques
Diseño De Colocación De Los Ladrillos
6
18
HANDLE
Twist spring handle on in a counter
clockwise motion. Spring handle will
“thread” down to desired location.
DESCRIPTION
PARTS LIST
1
DOOR ASSEMBLY
1
DOOR - NO GLASS
2&3
GLASS AND GASKET
1/8” GLASS GASKET
4
LARGE SPRING HANDLE
5
SMALL SPRING HANDLE
6
5/8” DOOR GASKET
7
GLASS CLIP
NUT
9
HINGE PIN
10
PUSH NUT
11
FIREBRICK LT 9”x4-7/16”x1-1/4”
12
FIREBRICK LT 4-1/2”x4-7/16”x1-1/4”
13
FIREBRICK LT - ANGLED
14
15
ITEM NO.
QTY
DESCRIPTION
NO.
LISTE DES PIÉCES
PORTE MONTÉE
PORTE - SANS LA VITRE
VITRE DE JOINT D’ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po
GRANDE POIGNÉE À RESSORT
JOINT DE LA PORTE 5/8po
FERRURE POUR LA VITRE
ÉCROU
GOUPILLE DE CHARNIÈRE
ÉCROU À RESSORT
BRIQUE 9”x4-7/16”x1-1/4”
BRIQUE 7-1/4”x4-7/16”x1-1/4”
BRIQUE - COUPLÉE EN ANGLE
LEYENDA
NO.
DESCRIPCIÓN
NO.de PC
LISTA DE PIEZAS
1
UNIDAD DE PUERTA
S31103
1
UNIDAD DE PUERTA SIN VIDRIO
S41075
1
VIDRIO Y EMPAQUETADURA
S31128
4.0’
EMPAQUETADURA DE 1/8” PARA EL VIDRO
S15001
1
POMO DE RESORTE, GRANDE
S11007
1
S11008
4.6’
EMPAQUETADURA DE 5/8” PARA LA PUERTA
S15011
2
PRESILLA PARA EL VIDRIO
S37020
7
TORNILLO
S11018
2
PASADOR DE BISAGRA
S11005
2
UNIDAD DEL DEFLECTOR
S11090
LADRILLO REFRACTARIO LT 9”x4-7/16”x1-1/4”
LADRILLO REFRACTARIO LT 7-1/4”x4-7/16”x1-1/4”
4
LADRILLO REFRACTARIO LT - ANGULADO
S16043
12
S16040
S16042
2
QTÉE
CANT. ART NO.
PART NO.
8
FIREBRICK LT 7-1/4”x4-7/16”x1-1/4”
FIREBRICK LT 4-7/16”x2-3/4”x1-1/4”
FIREBRICK FOR ASH DRAWER
ASH DRAWER ASSEMBLY
FERRURE POUR LA VITRE
PRESILLA PARA EL VIDRIO
1
S37021
BRIQUE 4-1/2”x4-7/16”x1-1/4”
BRIQUE 4-7/16”x2-3/4”x1-1/4”
LADRILLO REFRACTARIO LT 4-1/2”x4-7/16”x1-1/4”
LADRILLO REFRACTARIO LT 4-7/16”x2-3/4”x1-1/4”
BRIQUE POUR LE CENDRIER
LADRILLO PARA DEPÓSITO DE CENIZAS
L’ASSEMBLEE DE TROIR DE CENDRE
ASAMBLEA DE CAJON DE CENIZA
S16046
S16224
S16214
S31298
1
1
1
1
16
17
18
INLAY
GARNITURE DE LA PORTE
INCRUSTACION
1
S13144
3
GLASS CLIP
19
PETITE POIGNÉE À RESSORT
POMO DE RESORTE, PEQUEÑO
2
3
5
8
7
9
4
11
12
10
11
