HAND WINCH
* Strap not included
with all models
WARNING: NEVER EXCEED THE SPECIFIED LOAD CAPACITY INDICATED IN THE TABLE BELOW
INSTALLATION INSTRUCTIONS
WARNINGS (CONT)
WARNINGS
Avoid sideways cable slip and winch overloading.
The cable under a load should only be wound onto
the drum so that a minimum space of two times the
cable diameter remains on the drum flange.
Do not use any attachments to
extend the length of the winch cable.
Always leave at least five wraps of cable or belt on
the drum. Failure to do so may break cable connection
to the drum and could result in serious injury.
Make sure the winch base is properly bolted to a
structure or vehicle that can hold both the winch and
winch load. Failure to properly bolt down the winch
can result in personal injury and / or property damage.
After moving an object with the winch, secure
the object. Do not rely on the winch to hold an
object for an extended period of time.
Do not apply a load to the winch when the winch cable
is fully extended. The cable anchor on the winch is not
capable of holding the maximum rated load capacity.
When loading a boat onto a trailer without keel or side hull
rollers, make sure the trailer is submerged in the water when
the boat is loaded by the winch. Attempting to drag the boat
onto the trailer while on land can cause winch failure and
possibly personal injury and property damage.
Stand back and stay out of the direct line that the
winch cable is pulling. In the event the winch cable
slips or breaks, it will 'whip-lash' along this line.
Keep work area clean and dry; damp, cluttered and
wet areas invite injuries. Keep children away from the
work area and do not allow them to handle the winch.
Use eye and hand protection. Wear impact safety glasses
and heavy duty work gloves when using the winch.
Do not wear loose clothing or jewelry that can be caught
in moving parts. Wear protective hair covering to prevent
long hair from becoming caught. If wearing a long sleeve
shirt, roll the sleeves up to the elbows. Do not overreach
the winch. Keep proper footing and balance at all times to
prevent tripping, falling, back injury, etc.
Check for damaged parts and any other conditions that
may affect operation of this winch. Carefully check that it
will operate properly and perform its intended function.
Replace or repair damaged or worn parts immediately.
Check the rope, cable, or strap before each
use for signs of wear. If rope, cable, or strap
show signs of wear, replace immediately.
Always maintain a firm grip on the winch handle and do
not release the handle until the ratchet pawl is properly
engaged. Release handle slowly to be sure that ratchet lever
is fully supporting the load.
Never use a hand winch for lifting equipment or humans.
Read this manual carefully before installation or use of this
product. The warnings, cautions and instructions discussed
in this instruction manual cannot cover all possible conditions
or situations that could occur. It must be understood by the
operator that common sense and caution are factors which
cannot be built into the product and are the responsibility of
the end user.
Never exceed the maximum load capacity
as specified for each model in the table below.
Part#
Capacity
Gear Ratio
Handle Length
29427
1,700 lbs.
5.1:1
8"
29428
1,900 lbs.
5.1:1
8"
29429
2,100 lbs.
5.1:1
8"
29438*
1,900 lbs.
5.1:1
9 3/4"
* Winch strap included
PAGE 1 • 1.800.798.0813 • NEED ASSISTANCE?
• CURTMFG.COM
