POCKET MOD Electric Scooter Troubleshooting Guide
Issue
Symptom(s)
Troubleshoot
Result(s)
Possible Solution(s)
Product Does Not Run
Unit shut off while in use
Lights on throttle do
NOT
light up
Remove battery/motor cover & check fuse
located next to battery
Fuse burnt out
Replace fuse and correct riding
conditions. (Refer to Pg 6 in Owners
Manual)
Lights on throttle do
NOT
light up
Motor will not engage
Remove battery/motor cover to
check for loose connection(s)
Loose connection(s)
Reconnect Loose Connection(s)
Motor engages, but unit
will not move
Check chain & rear wheel
Chain is rotating, but rear wheel does not
move
Replace Rear Wheel
Secure unit; turn power on & with
NO
weight on the unit, lift back end up
& apply the throttle
Rear Wheel Spins Freely
Replace Battery or Charger
*
Unit should be charged 12 hours before
first initial use and up to 8 hours after each
subsequent use
Motor engages
Replace Brake Lever
Motor does
NOT
engage
Replace Control Module & Throttle
Product Stops Without
Applying Brakes
Unit shut off while in use
Remove battery/motor cover & check fuse
located next to battery
Fuse burnt out
Replace fuse and correct riding
conditions. (Refer to Pg 6 in Owners
Manual)
Lights on throttle do
NOT
light up
Motor will not engage
Remove battery/motor cover to
check for loose connection(s)
Loose connection(s)
Reconnect Loose Connection(s)
Chain too loose
Adjust chain
Chain slipped off rear sprocket
Check chain for possible damage
[Replace chain if necessary]
(Refer to Pg 5 in Owner's Manual)
Chain is jammed in chain
tensioner
Remove chain from chain tensioner;
check chain & chain tensioner for
possible damage
[Replace part(s) if necessary];
place chain back on rear sprocket
(Refer to Pg 5 in Owners manual)
Turn power off & manually turn gear on
motor shaft with your fingers
Gear does
NOT
turn freely
Replace Motor
*
Always check to make sure charger is
plugged into charger port correctly & lights
on charger are working properly
Lights on throttle light up
Check tension; position & the
condition of chain
Remove battery/motor cover & unplug
brake connector from control module
Secure unit; turn power on
& apply throttle
Lights on throttle light up
Unit worked, but
will not go after charging
12/21/2006
1
