Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
IMPORTANT WARRANTY INFORMATION: KEEP YOUR ROADSTART HEALTHY
Read and understand the general safety and operating instructions before use. The following information is intended to help
you keep the product in top working order.
NOTE – The battery in this unit is a consumable item and its ability to accept charge will reduce over time. We will warrant it
against mechanical and electrical defect for a period of one year - this does not cover fair wear and tear.
If the battery is not properly charged before first use, or regularly conditioned, its capacity will diminish. Under these circumstances we
will not replace the battery even if it is less than one year old.
T
he Reverse Charging Protection Diode, fitted in the positive lead, is a consumable part that is damaged by failure to adhere to the
duty cycle instructions.
You can help prolong the life cycle of the battery by following a few simple guidelines:
•
Plug in your new RoadStart to the mains transformer and make an INITIAL charge lasting 72 hours.
•
Ensure the unit is fully charged before storage.
•
DO NOT
leave the RoadStart for longer than 2 months without putting it on charge.
•
DO NOT
attempt to start a vehicle when the RoadStart battery voltage is reduced to less than 7V.
•
DO NOT
drop or handle the RoadStart roughly – this will break or disconnect the battery terminals rendering the battery useless and
the warranty void.
•
DO NOT
use any other charger, other than the one supplied, to recharge the battery.
•
DO NOT
obstruct the ventilation grilles and protect against water ingress - these RoadStart units are fitted with ventilation grilles to
help disperse any gases produced during the charging procedure.
1. SAFETY
IMPORTANT:
To reduce the risk of a battery explosion, follow these instructions and those published by the battery manufacturer and the
manufacturer of any equipment you intend to use in the vicinity of the battery. Remember to review warning marks on all products and on engines.
Modern vehicles contain extensive electronic systems.
Y
ou are required to check with the vehicle manufacturer, for any specific instructions regarding the use of this type of equipment on each
vehicle. No liability will be accepted for damage / injury, where this product is not used in accordance with all instructions.
1.1.
PERSONAL PRECAUTIONS
9
Ensure there is another person within hearing range, or close enough to come to your aid should a problem arise, when working near
a lead-acid battery.
9
Have fresh water and soap nearby in case battery acid contacts skin, clothing or eyes.
9
Wear safety eye protection and protective clothing. Avoid touching eyes while working with a battery.
9
Wash immediately with soap and water if battery acid contacts skin or clothing. If acid enters eye, flush eye immediately with cool, clean
running water for at least 15 minutes and seek immediate medical attention.
9
Remove personal metallic items such as rings, bracelets, necklaces and watches. A lead-acid battery can produce a short-circuit current
9
high enough to weld a ring or the like to metal, which may cause severe burns.
1.2.
IMPORTANT SAFETY INSTRUCTIONS
9
Familiarise yourself with the applications, limitations and potential hazards of the RoadStart.
9
Keep the unit in good working order and condition. Replace damaged parts immediately.
9
Use only recommended parts. To use unapproved parts may be dangerous and will invalidate your warranty.
9
The RoadStart must only be opened and checked by qualified service personnel.
DO NOT
disassemble the unit for any reason.
9
Keep children and unauthorised persons away from the work area.
9
Keep work area clean and tidy and free from unrelated materials. Ensure that there is adequate lighting.
9
If the RoadStart receives a sharp knock or blow, it must be checked by a qualified service agent before being used.
9
When not in use re-charge every two months.
8
8
88
DO NOT
touch positive and negative clamps together as this could cause an explosion.
8
8
88
DO NOT
smoke or allow a spark, or flame in the vicinity of the battery or engine.
8
8
88
DO NOT
drop any metal item onto the battery as it may spark or short circuit the battery, which could cause an explosion.
8
8
88
DO NOT
use RoadStart to recharge dry cell batteries that are commonly used with home appliances. These batteries may explode and
cause personal injury and damage to property.
8
8
88
DO NOT
charge or boost a frozen battery.
RS125.V4| Issue:1 10/01/17
Original Language Version
© Jack Sealey Limited
INSTRUcTIoNS FoR:
ROADSTART UNIT
ModEL No:
RS125.V4
Refer to Instruction
Manual
Warning:
Explosive Material
Use in Well
Ventilated Areas
Wear
Protective
Gloves
Wear
Eye
Protection
Keep Away From
Sources of Ignition;
Battery could
Explode