LIMITED WARRANTY
WESCO INDUSTRIAL PRODUCTS (WESCO) warrants to the purchaser of this product for a period of ninety (90) days from the date of purchase that this product shall be free of
defects in material and/or workmanship, as follows:
1. WESCO will supply, at no charge, new or rebuilt replacements for any part that fails through a defect in material and/or workmanship during the warranty period. To obtain warranty
service, you must deliver the product prepaid, to the WESCO factory.
2. This warranty does not cover any product or product part which has been subject to accident, misuse, abuse or negligence. WESCO shall only be liable under this warranty if the
product is used the manner intended by the manufacturer as specified in the written instructions furnished with this product.
REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER. ANY EXPRESS WARRANTY NOT PROVIDED IN
THIS WARRANTY DOCUMENT, AND ANY REMEDY FOR BREACH OF CONTRACT THAT, BUT FOR THIS PROVISION, MIGHT ARISE BY IMPLICATION OR OPERATION OF LAW,
IS HEREBY EXCLUDED AND DISCLAIMED. UNDER NO CIRCUMSTANCES SHALL WESCO BE LIABLE TO PURCHASER OR ANY OTHER PERSON FOR ANY INCIDENTAL OR
CONSEQUENTIAL DAMAGES, WHETHER ARISING OUT OF BREACH OF WARRANTY, EXPRESS OR IMPLIED, A BREACH OF CONTRACT OR OTHERWISE. EXCEPT TO THE
EXTENT PROHIBITED BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR ANY PARTICULAR PURPOSE ARE EXPRESSLY LIMITED
IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Some states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations on how long any implied warranty lasts, so the above limitations may not
apply to you. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
Description
The Wesco Fork Mounted Drum Grabs are designed for the
transport of steel drums with a powered fork truck.
Wesco Industrial Products, Inc
1250 Welsh Road
North Wales, PA 19454
Tel: 215-699-7031 Fax: 215-699-3836
Contact the factory for parts information and ordering.
Visit us on the web at www.wescomfg.com
Unpacking
When unpacking the Wesco Product, check carefully for
shipping damage and missing parts. If damage has occurred
or any parts are missing, file a claim with the delivering carrier
within 24 hours and notify the dealer from whom the unit was
purchased.
Warranty Repairs
If the unit does not work properly, contact your dealer or the
factory (215-699-7031) for units less than 90 days old.
Non-Warranty Service
If units are older than 90 days, repairs can be made easily on
site with factory supplied parts.
NOTE:
Do not send units to the factory for service without
first obtaining a “Return Merchandise Authorization” (RMA)
number from the customer service department. We will not
be responsible for merchandise returned without proper
authorization.
Figure 1
Fork Mounted Drum Grabs: DJ-55, DJL-55,
DJ-255, ADJ-53, ADJL-53, ADJ-253
(Part #’s 240048, 270051, 240049, 240047, 270084, 240066)
Operating Instructions and Parts Manual
ATTENTION: TO INSURE SAFE AND EASY USE OF YOUR WESCO DRUM
GRAB, READ THESE INSTRUCTIONS BEFORE USING.
General Safety Information
The Wesco Fork Mounted Drum Grabs is designed for
specific functions. To insure proper use, the following
instructions must be adhered to:
(1) Load Ratings:
-
DJ-55
: One 55 Gallon Drum (1,500 lbs capacity)
-
DJL-55
: One 55 Gallon Drum (1,500 lbs capacity)
-
DJ-255
: Two 55 Gallon Drums (1,500 lbs/per drum
capacity)
-
ADJ-53
: One 55 or 30 Gallon Drum (1,500 lbs
capacity)
-
ADJL
-
53
: One 55 or 30 Gallon Drum (1,500 lbs
capacity)
-
ADJ-253
: Two 55 or 30 Gallon Drums (1,500 lbs/per
drum capacity)
(2) DO NOT use your unit for loads exceeding the rated
capacity.
(3) DO NOT use on open head drums containing liquid or
powder.
(4) DO NOT use on fiber or plastic drums.
(5) Drums must have rolling ribs, and should not have
severe dents or be otherwise misshaped.
(6) Follow all Occupational Safety and Health Act (OSHA)
requirements, particularly Section 1910.178a(5)
regarding powered industrial trucks.
(7) Adhere to all local codes regarding drum use and
storage.
(8) Before using this product, contact the manufacturer of
your industrial truck, and obtain their written approval
that the truck has the capacity to be used with this
attachment.
(9) DO NOT use drum grabs with manually operated
stackers.
(10) DO NOT use to lift personnel or to carry loads over
people.
(11) DO NOT leave with a load suspended in air unattended.
(12) DO NOT remove or obscure capacity/warning label.
(13) Inspect unit daily before use. Remove unit from service
immediately if damaged or malfunctioning until repairs
have been made.
(14) DO NOT modify this product in any way.
(15) Use only genuine WESCO replacement parts when
servicing.
Industrial Products, Inc.
